AP2 2004–05 (F22C1, cable) → rusEFI Proteus (auto)
AP2 2004–05 (F22C1, cable) — rusEFI — Proteus
⚠ NOT CHECKED. Don't build from this.
Drawn by Michael Gnankou · Rev 0 · draft · 2026-10-08
Before you start
| Status | draft · not yet verified: nobody has reported building and running this harness |
|---|---|
| Open errors | none |
| Size of the job | 76 wires · 10 connectors · 4 part lines |
| Tools | Crimp and extraction tools for each terminal family (see Connectors) · wire strippers · multimeter · heat gun + heat-shrink |
| Order of work | 1. Check every part against the parts list. 2. Cut and label every wire (labels: Export → Wire labels). 3. Crimp and pin connector by connector, ticking the build checklist. 4. Run the bench test with nothing plugged in and the battery disconnected. 5. Only then connect the ECU and power up. |
Build checklist
Tick each box as you go. Continuity: meter from end to end, expect under 1 Ω.
| Wire | From | To | Gauge | Colour | Cut | Label | Crimp A | Crimp B | Pin A | Pin B | Continuity |
|---|---|---|---|---|---|---|---|---|---|---|---|
| W1 | OEM-B-1 | SP-14V-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W2 | OEM-B-9 | SP-14V-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W3 | SP-14V-1 | PROTEUS-Black23-23 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W4 | OEM-B-10 | SP-GND-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W5 | OEM-B-2 | SP-GND-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W6 | OEM-B-20 | SP-GND-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W7 | OEM-B-22 | SP-GND-1 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W8 | SP-GND-1 | PROTEUS-Black23-14 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W9 | SP-GND-1 | PROTEUS-Black23-19 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W10 | SP-GND-1 | PROTEUS-Black23-20 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W11 | SP-GND-1 | PROTEUS-Black35-17 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W12 | SP-GND-1 | PROTEUS-Black35-18 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W13 | SP-GND-1 | PROTEUS-Black35-24 | 0.85 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W14 | OEM-C-18 | SP-0V-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W15 | OEM-C-30 | SP-0V-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W16 | OEM-C-31 | SP-0V-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W17 | OEM-C-7 | SP-0V-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W18 | SP-0V-1 | PROTEUS-White35-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W19 | SP-0V-1 | PROTEUS-White35-2 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W20 | SP-0V-1 | PROTEUS-White35-23 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W21 | SP-0V-1 | PROTEUS-White35-29 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W22 | SP-0V-1 | PROTEUS-White35-3 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W23 | SP-0V-1 | PROTEUS-White35-4 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W24 | SP-0V-1 | PROTEUS-White35-5 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W25 | SP-0V-1 | PROTEUS-White35-6 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W26 | SP-0V-1 | PROTEUS-White35-7 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W27 | SP-0V-1 | PROTEUS-White35-8 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W28 | OEM-C-19 | PROTEUS-White35-10 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W29 | OEM-C-28 | PROTEUS-White35-21 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W30 | OEM-C-9 | PROTEUS-Black23-13 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W31 | OEM-C-8 | PROTEUS-Black23-5 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W32 | OEM-C-21 | PROTEUS-Black23-12 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W33 | OEM-C-20 | PROTEUS-Black23-4 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W34 | OEM-C-29 | PROTEUS-Black23-1 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W35 | OEM-C-4 | PROTEUS-Black35-35 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W36 | OEM-C-12 | PROTEUS-Black35-34 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W37 | OEM-C-13 | PROTEUS-Black35-22 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W38 | OEM-C-14 | PROTEUS-Black35-33 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W39 | OEM-B-11 | PROTEUS-Black35-3 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W40 | OEM-B-3 | PROTEUS-Black35-15 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W41 | OEM-B-4 | PROTEUS-Black35-4 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W42 | OEM-B-5 | PROTEUS-Black35-16 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W43 | OEM-A-15 | PROTEUS-Black35-20 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W44 | OEM-A-16 | PROTEUS-Black35-9 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W45 | OEM-A-17 | PROTEUS-Black35-21 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W46 | OEM-A-20 | PROTEUS-Black35-10 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W47 | OEM-A-28 | PROTEUS-Black35-11 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W48 | OEM-B-12 | PROTEUS-Black35-2 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W49 | OEM-C-1 | PROTEUS-Black35-12 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W50 | OEM-C-11 | PROTEUS-Black35-23 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W51 | OEM-B-23 | PROTEUS-Black35-5 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W52 | OEM-A-1 | PROTEUS-Black35-6 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W53 | OEM-A-12 | PROTEUS-Black35-7 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W54 | OEM-A-18 | PROTEUS-Black35-19 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W55 | OEM-A-2 | PROTEUS-Black35-8 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W56 | OEM-A-3 | PROTEUS-Black23-6 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W57 | OEM-A-4 | PROTEUS-Black23-7 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W58 | OEM-A-6 | PROTEUS-Black23-15 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W59 | OEM-C-2 | PROTEUS-Black23-8 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W60 | OEM-C-17 | PROTEUS-White35-13 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W61 | OEM-C-27 | PROTEUS-White35-24 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W62 | OEM-A-23 | PROTEUS-White35-14 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W63 | OEM-C-15 | PROTEUS-White35-25 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W64 | OEM-C-16 | PROTEUS-White35-15 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W65 | OEM-C-26 | PROTEUS-White35-20 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W66 | OEM-C-25 | PROTEUS-White35-30 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W67 | OEM-A-29 | PROTEUS-White35-26 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W68 | OEM-A-30 | PROTEUS-White35-16 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W69 | OEM-C-24 | PROTEUS-White35-27 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W70 | OEM-A-9 | PROTEUS-Black23-2 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W71 | OEM-C-5 | PROTEUS-Black23-10 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W72 | OEM-A-24 | PROTEUS-Black23-3 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W73 | OEM-A-26 | PROTEUS-Black23-9 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W74 | OEM-A-27 | PROTEUS-Black23-11 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W75 | OEM-A-32 | PROTEUS-White35-17 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | |
| W76 | OEM-C-10 | PROTEUS-White35-28 | 0.5 | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ | ☐ |
Bench test (before first power-up)
Battery disconnected, ECU and every sensor unplugged. Meter on resistance. Each pair below must read open (OL): a reading means a pinched wire, a stray strand or a mis-pinned cavity. Then check continuity of every wire (last column of the build checklist).
| # | Probe A | Probe B | Expect | Why | Reading |
|---|---|---|---|---|---|
| 1 | PROTEUS-Black23-23 | PROTEUS-Black23-14 | open (OL) | +12 V supply must not touch power ground | |
| 2 | PROTEUS-Black23-23 | PROTEUS-White35-1 | open (OL) | +12 V supply must not touch sensor ground | |
| 3 | PROTEUS-Black23-14 | PROTEUS-White35-10 | open (OL) | power ground must not touch 5 V sensor reference | |
| 4 | PROTEUS-Black23-14 | PROTEUS-White35-21 | open (OL) | power ground must not touch 5 V sensor reference | |
| 5 | PROTEUS-Black23-23 | PROTEUS-White35-10 | open (OL) | +12 V supply must not touch 5 V sensor reference | |
| 6 | PROTEUS-Black23-23 | PROTEUS-White35-21 | open (OL) | +12 V supply must not touch 5 V sensor reference | |
| 7 | PROTEUS-White35-1 | PROTEUS-White35-10 | open (OL) | sensor ground must not touch 5 V sensor reference | |
| 8 | PROTEUS-White35-1 | PROTEUS-White35-21 | open (OL) | sensor ground must not touch 5 V sensor reference |
Revisions
| Rev | Label | By | Date |
|---|---|---|---|
| No revisions yet. | |||
Schematic
Connectors
OEM-A
Mating face
Wire side
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Coolant temp gauge drive | — | W52 | — | 0.5 | PROTEUS-Black35-6 | — | — | — |
| 2 | Air control valve solenoid | — | W55 | — | 0.5 | PROTEUS-Black35-8 | — | — | — |
| 3 | Evap bypass solenoid | — | W56 | — | 0.5 | PROTEUS-Black23-6 | — | — | — |
| 4 | Evap canister vent shut valve | — | W57 | — | 0.5 | PROTEUS-Black23-7 | — | — | — |
| 5 | NC | — | — | — | — | — | — | — | — |
| 6 | Evap canister purge valve | — | W58 | — | 0.5 | PROTEUS-Black23-15 | — | — | — |
| 7 | NC | — | — | — | — | — | — | — | — |
| 8 | NC | — | — | — | — | — | — | — | — |
| 9 | Vehicle speed sensor | — | W70 | — | 0.5 | PROTEUS-Black23-2 | — | — | — |
| 10 | Service check signal | — | — | — | — | — | — | — | — |
| 11 | NC | — | — | — | — | — | — | — | — |
| 12 | Immobilizer indicator light | — | W53 | — | 0.5 | PROTEUS-Black35-7 | — | — | — |
| 13 | Immobilizer enable signal | — | — | — | — | — | — | — | — |
| 14 | NC | — | — | — | — | — | — | — | — |
| 15 | Fuel pump relay (USDM) | — | W43 | — | 0.5 | PROTEUS-Black35-20 | — | — | — |
| 16 | Fuel pump relay (JDM) | — | W44 | — | 0.5 | PROTEUS-Black35-9 | — | — | — |
| 17 | A/C clutch relay | — | W45 | — | 0.5 | PROTEUS-Black35-21 | — | — | — |
| 18 | Check engine light (MIL) | — | W54 | — | 0.5 | PROTEUS-Black35-19 | — | — | — |
| 19 | Tacho output | — | — | — | — | — | — | — | — |
| 20 | Radiator fan relay | — | W46 | — | 0.5 | PROTEUS-Black35-10 | — | — | — |
| 21 | K-Line | — | — | — | — | — | — | — | — |
| 22 | NC | — | — | — | — | — | — | — | — |
| 23 | Secondary O2 sensor | — | W62 | — | 0.5 | PROTEUS-White35-14 | — | — | — |
| 24 | Starter switch signal | — | W72 | — | 0.5 | PROTEUS-Black23-3 | — | — | — |
| 25 | Immobilizer code | — | — | — | — | — | — | — | — |
| 26 | Power steering load detect | — | W73 | — | 0.5 | PROTEUS-Black23-9 | — | — | — |
| 27 | A/C switch (request) | — | W74 | — | 0.5 | PROTEUS-Black23-11 | — | — | — |
| 28 | Air pump relay | — | W47 | — | 0.5 | PROTEUS-Black35-11 | — | — | — |
| 29 | Fuel tank pressure sensor | — | W67 | — | 0.5 | PROTEUS-White35-26 | — | — | — |
| 30 | Electrical load detector | — | W68 | — | 0.5 | PROTEUS-White35-16 | — | — | — |
| 31 | NC | — | — | — | — | — | — | — | — |
| 32 | Brake switch | — | W75 | — | 0.5 | PROTEUS-White35-17 | — | — | — |
OEM-B
Mating face
Wire side
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Power source 1 (main relay) | — | W1 | — | 0.85 | SP-14V-1 | — | — | — |
| 2 | Power ground 1 | — | W5 | — | 0.85 | SP-GND-1 | — | — | — |
| 3 | Injector 2 | — | W40 | — | 0.5 | PROTEUS-Black35-15 | — | — | — |
| 4 | Injector 3 | — | W41 | — | 0.5 | PROTEUS-Black35-4 | — | — | — |
| 5 | Injector 4 | — | W42 | — | 0.5 | PROTEUS-Black35-16 | — | — | — |
| 6 | NC | — | — | — | — | — | — | — | — |
| 7 | NC | — | — | — | — | — | — | — | — |
| 8 | NC | — | — | — | — | — | — | — | — |
| 9 | Power source 2 (main relay) | — | W2 | — | 0.85 | SP-14V-1 | — | — | — |
| 10 | Power ground 2 | — | W4 | — | 0.85 | SP-GND-1 | — | — | — |
| 11 | Injector 1 | — | W39 | — | 0.5 | PROTEUS-Black35-3 | — | — | — |
| 12 | VTEC solenoid | — | W48 | — | 0.5 | PROTEUS-Black35-2 | — | — | — |
| 13 | NC | — | — | — | — | — | — | — | — |
| 14 | NC | — | — | — | — | — | — | — | — |
| 15 | NC | — | — | — | — | — | — | — | — |
| 16 | NC | — | — | — | — | — | — | — | — |
| 17 | NC | — | — | — | — | — | — | — | — |
| 18 | NC | — | — | — | — | — | — | — | — |
| 19 | NC | — | — | — | — | — | — | — | — |
| 20 | Ground | — | W6 | — | 0.85 | SP-GND-1 | — | — | — |
| 21 | Backup power (battery constant) | — | — | — | — | — | — | — | — |
| 22 | Ground | — | W7 | — | 0.85 | SP-GND-1 | — | — | — |
| 23 | Idle air control valve | — | W51 | — | 0.5 | PROTEUS-Black35-5 | — | — | — |
| 24 | NC | — | — | — | — | — | — | — | — |
| 25 | NC | — | — | — | — | — | — | — | — |
OEM-C
Mating face
Wire side
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Primary O2 heater | — | W49 | — | 0.5 | PROTEUS-Black35-12 | — | — | — |
| 2 | Alternator control | — | W59 | — | 0.5 | PROTEUS-Black23-8 | — | — | — |
| 3 | Knock sensor | — | — | — | — | — | — | — | — |
| 4 | Ignition coil 1 | — | W35 | — | 0.5 | PROTEUS-Black35-35 | — | — | — |
| 5 | Alternator FR signal | — | W71 | — | 0.5 | PROTEUS-Black23-10 | — | — | — |
| 6 | NC | — | — | — | — | — | — | — | — |
| 7 | Sensor ground 1 | — | W17 | — | 0.5 | SP-0V-1 | — | — | — |
| 8 | Crank sensor + (CKP+) | — | W31 | — | 0.5 | PROTEUS-Black23-5 | — | — | — |
| 9 | Crank sensor − (CKP−) | — | W30 | — | 0.5 | PROTEUS-Black23-13 | — | — | — |
| 10 | VTEC pressure switch | — | W76 | — | 0.5 | PROTEUS-White35-28 | — | — | — |
| 11 | Secondary O2 heater control | — | W50 | — | 0.5 | PROTEUS-Black35-23 | — | — | — |
| 12 | Ignition coil 2 | — | W36 | — | 0.5 | PROTEUS-Black35-34 | — | — | — |
| 13 | Ignition coil 3 | — | W37 | — | 0.5 | PROTEUS-Black35-22 | — | — | — |
| 14 | Ignition coil 4 | — | W38 | — | 0.5 | PROTEUS-Black35-33 | — | — | — |
| 15 | Secondary O2 sensor | — | W63 | — | 0.5 | PROTEUS-White35-25 | — | — | — |
| 16 | Primary O2 sensor | — | W64 | — | 0.5 | PROTEUS-White35-15 | — | — | — |
| 17 | MAP sensor | — | W60 | — | 0.5 | PROTEUS-White35-13 | — | — | — |
| 18 | Sensor ground 2 | — | W14 | — | 0.5 | SP-0V-1 | — | — | — |
| 19 | Sensor 5V supply 1 (MAP) | — | W28 | — | 0.5 | PROTEUS-White35-10 | — | — | — |
| 20 | Cam (TDC1) sensor + | — | W33 | — | 0.5 | PROTEUS-Black23-4 | — | — | — |
| 21 | Cam (TDC1) sensor − | — | W32 | — | 0.5 | PROTEUS-Black23-12 | — | — | — |
| 22 | Knock sensor | — | — | — | — | — | — | — | — |
| 23 | NC | — | — | — | — | — | — | — | — |
| 24 | Air pump electric current sensor | — | W69 | — | 0.5 | PROTEUS-White35-27 | — | — | — |
| 25 | Intake air temp sensor | — | W66 | — | 0.5 | PROTEUS-White35-30 | — | — | — |
| 26 | Coolant temp sensor | — | W65 | — | 0.5 | PROTEUS-White35-20 | — | — | — |
| 27 | Throttle position sensor | — | W61 | — | 0.5 | PROTEUS-White35-24 | — | — | — |
| 28 | Sensor 5V supply 2 | — | W29 | — | 0.5 | PROTEUS-White35-21 | — | — | — |
| 29 | Cam (TDC2) sensor + | — | W34 | — | 0.5 | PROTEUS-Black23-1 | — | — | — |
| 30 | Cam (TDC2) sensor − | — | W15 | — | 0.5 | SP-0V-1 | — | — | — |
| 31 | Timing ground | — | W16 | — | 0.5 | SP-0V-1 | — | — | — |
OEM-D
Mating face
Wire side
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | NC | — | — | — | — | — | — | — | — |
| 2 | NC | — | — | — | — | — | — | — | — |
| 3 | NC | — | — | — | — | — | — | — | — |
| 4 | NC | — | — | — | — | — | — | — | — |
| 5 | NC | — | — | — | — | — | — | — | — |
| 6 | NC | — | — | — | — | — | — | — | — |
| 7 | NC | — | — | — | — | — | — | — | — |
| 8 | NC | — | — | — | — | — | — | — | — |
| 9 | NC | — | — | — | — | — | — | — | — |
| 10 | NC | — | — | — | — | — | — | — | — |
| 11 | NC | — | — | — | — | — | — | — | — |
| 12 | NC | — | — | — | — | — | — | — | — |
| 13 | NC | — | — | — | — | — | — | — | — |
| 14 | NC | — | — | — | — | — | — | — | — |
| 15 | NC | — | — | — | — | — | — | — | — |
| 16 | NC | — | — | — | — | — | — | — | — |
PROTEUS-Black23
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Digital 2 | — | W34 | — | 0.5 | OEM-C-29 | — | — | — |
| 10 | Digital 1 | — | W71 | — | 0.5 | OEM-C-5 | — | — | — |
| 11 | Digital 6 | — | W74 | — | 0.5 | OEM-A-27 | — | — | — |
| 12 | VR 2 negative | — | W32 | — | 0.5 | OEM-C-21 | — | — | — |
| 13 | VR 1 negative | — | W30 | — | 0.5 | OEM-C-9 | — | — | — |
| 14 | Power ground | — | W8 | — | 0.85 | SP-GND-1 | — | — | — |
| 15 | ETB 2 positive | — | W58 | — | 0.5 | OEM-A-6 | — | — | — |
| 16 | CAN 1 Low | — | — | — | — | — | — | — | — |
| 17 | CAN 1 High | — | — | — | — | — | — | — | — |
| 18 | Ignition switch in | — | — | — | — | — | — | — | — |
| 19 | Power ground | — | W9 | — | 0.85 | SP-GND-1 | — | — | — |
| 2 | Digital 3 | — | W70 | — | 0.5 | OEM-A-9 | — | — | — |
| 20 | Power ground | — | W10 | — | 0.85 | SP-GND-1 | — | — | — |
| 21 | CAN 2 Low | — | — | — | — | — | — | — | — |
| 22 | CAN 2 High | — | — | — | — | — | — | — | — |
| 23 | Main relay feed | — | W3 | — | 0.85 | SP-14V-1 | — | — | — |
| 3 | Digital 4 | — | W72 | — | 0.5 | OEM-A-24 | — | — | — |
| 4 | VR 2 positive | — | W33 | — | 0.5 | OEM-C-20 | — | — | — |
| 5 | VR 1 positive | — | W31 | — | 0.5 | OEM-C-8 | — | — | — |
| 6 | ETB 1 negative | — | W56 | — | 0.5 | OEM-A-3 | — | — | — |
| 7 | ETB 1 positive | — | W57 | — | 0.5 | OEM-A-4 | — | — | — |
| 8 | ETB 2 negative | — | W59 | — | 0.5 | OEM-C-2 | — | — | — |
| 9 | Digital 5 | — | W73 | — | 0.5 | OEM-A-26 | — | — | — |
PROTEUS-Black35
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Highside 2 | — | — | — | — | — | — | — | — |
| 10 | Lowside 13 | — | W46 | — | 0.5 | OEM-A-20 | — | — | — |
| 11 | Lowside 14 | — | W47 | — | 0.5 | OEM-A-28 | — | — | — |
| 12 | Lowside 15 | — | W49 | — | 0.5 | OEM-C-1 | — | — | — |
| 13 | Highside 3 | — | — | — | — | — | — | — | — |
| 14 | Highside 4 | — | — | — | — | — | — | — | — |
| 15 | Injector 2 | — | W40 | — | 0.5 | OEM-B-3 | — | — | — |
| 16 | Injector 4 | — | W42 | — | 0.5 | OEM-B-5 | — | — | — |
| 17 | Power ground | — | W11 | — | 0.85 | SP-GND-1 | — | — | — |
| 18 | Power ground | — | W12 | — | 0.85 | SP-GND-1 | — | — | — |
| 19 | Injector 8 | — | W54 | — | 0.5 | OEM-A-18 | — | — | — |
| 2 | Highside 1 | — | W48 | — | 0.5 | OEM-B-12 | — | — | — |
| 20 | Lowside 10 | — | W43 | — | 0.5 | OEM-A-15 | — | — | — |
| 21 | Lowside 12 | — | W45 | — | 0.5 | OEM-A-17 | — | — | — |
| 22 | Ignition 3 | — | W37 | — | 0.5 | OEM-C-13 | — | — | — |
| 23 | Lowside 16 | — | W50 | — | 0.5 | OEM-C-11 | — | — | — |
| 24 | Power ground | — | W13 | — | 0.85 | SP-GND-1 | — | — | — |
| 25 | Ignition 12 | — | — | — | — | — | — | — | — |
| 26 | Ignition 11 | — | — | — | — | — | — | — | — |
| 27 | Ignition 10 | — | — | — | — | — | — | — | — |
| 28 | Ignition 9 | — | — | — | — | — | — | — | — |
| 29 | Ignition 8 | — | — | — | — | — | — | — | — |
| 3 | Injector 1 | — | W39 | — | 0.5 | OEM-B-11 | — | — | — |
| 30 | Ignition 7 | — | — | — | — | — | — | — | — |
| 31 | Ignition 6 | — | — | — | — | — | — | — | — |
| 32 | Ignition 5 | — | — | — | — | — | — | — | — |
| 33 | Ignition 4 | — | W38 | — | 0.5 | OEM-C-14 | — | — | — |
| 34 | Ignition 2 | — | W36 | — | 0.5 | OEM-C-12 | — | — | — |
| 35 | Ignition 1 | — | W35 | — | 0.5 | OEM-C-4 | — | — | — |
| 4 | Injector 3 | — | W41 | — | 0.5 | OEM-B-4 | — | — | — |
| 5 | Injector 5 | — | W51 | — | 0.5 | OEM-B-23 | — | — | — |
| 6 | Injector 6 | — | W52 | — | 0.5 | OEM-A-1 | — | — | — |
| 7 | Injector 7 | — | W53 | — | 0.5 | OEM-A-12 | — | — | — |
| 8 | Injector 9 | — | W55 | — | 0.5 | OEM-A-2 | — | — | — |
| 9 | Lowside 11 | — | W44 | — | 0.5 | OEM-A-16 | — | — | — |
PROTEUS-White35
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | Sensor ground | — | W18 | — | 0.5 | SP-0V-1 | — | — | — |
| 10 | 5V supply #2 | — | W28 | — | 0.5 | OEM-C-19 | — | — | — |
| 11 | 12V sensor supply | — | — | — | — | — | — | — | — |
| 12 | 12V sensor supply | — | — | — | — | — | — | — | — |
| 13 | Analog Volt 1 | — | W60 | — | 0.5 | OEM-C-17 | — | — | — |
| 14 | Analog Volt 3 | — | W62 | — | 0.5 | OEM-A-23 | — | — | — |
| 15 | Analog Volt 5 | — | W64 | — | 0.5 | OEM-C-16 | — | — | — |
| 16 | Analog Volt 7 | — | W68 | — | 0.5 | OEM-A-30 | — | — | — |
| 17 | Analog Volt 9 | — | W75 | — | 0.5 | OEM-A-32 | — | — | — |
| 18 | Analog Volt 11 | — | — | — | — | — | — | — | — |
| 19 | Thermistor 1 | — | — | — | — | — | — | — | — |
| 2 | Sensor ground | — | W19 | — | 0.5 | SP-0V-1 | — | — | — |
| 20 | Coolant temp (CLT) | — | W65 | — | 0.5 | OEM-C-26 | — | — | — |
| 21 | 5V supply #1 | — | W29 | — | 0.5 | OEM-C-28 | — | — | — |
| 22 | 5V supply #2 | — | — | — | — | — | — | — | — |
| 23 | Sensor ground | — | W20 | — | 0.5 | SP-0V-1 | — | — | — |
| 24 | Analog Volt 2 | — | W61 | — | 0.5 | OEM-C-27 | — | — | — |
| 25 | Analog Volt 4 | — | W63 | — | 0.5 | OEM-C-15 | — | — | — |
| 26 | Analog Volt 6 | — | W67 | — | 0.5 | OEM-A-29 | — | — | — |
| 27 | Analog Volt 8 | — | W69 | — | 0.5 | OEM-C-24 | — | — | — |
| 28 | Analog Volt 10 | — | W76 | — | 0.5 | OEM-C-10 | — | — | — |
| 29 | Sensor ground | — | W21 | — | 0.5 | SP-0V-1 | — | — | — |
| 3 | Sensor ground | — | W22 | — | 0.5 | SP-0V-1 | — | — | — |
| 30 | Intake air temp (IAT) | — | W66 | — | 0.5 | OEM-C-25 | — | — | — |
| 31 | Thermistor 4 | — | — | — | — | — | — | — | — |
| 32 | 5V supply #1 | — | — | — | — | — | — | — | — |
| 33 | 5V supply #2 | — | — | — | — | — | — | — | — |
| 34 | Knock 1 | — | — | — | — | — | — | — | — |
| 35 | Knock 2 | — | — | — | — | — | — | — | — |
| 4 | Sensor ground | — | W23 | — | 0.5 | SP-0V-1 | — | — | — |
| 5 | Sensor ground | — | W24 | — | 0.5 | SP-0V-1 | — | — | — |
| 6 | Sensor ground | — | W25 | — | 0.5 | SP-0V-1 | — | — | — |
| 7 | Sensor ground | — | W26 | — | 0.5 | SP-0V-1 | — | — | — |
| 8 | Sensor ground | — | W27 | — | 0.5 | SP-0V-1 | — | — | — |
| 9 | 5V supply #1 | — | — | — | — | — | — | — | — |
SP-0V
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | — | — | W14 | — | 0.5 | OEM-C-18 | — | — | — |
| 1 | — | — | W15 | — | 0.5 | OEM-C-30 | — | — | — |
| 1 | — | — | W16 | — | 0.5 | OEM-C-31 | — | — | — |
| 1 | — | — | W17 | — | 0.5 | OEM-C-7 | — | — | — |
| 1 | — | — | W18 | — | 0.5 | PROTEUS-White35-1 | — | — | — |
| 1 | — | — | W19 | — | 0.5 | PROTEUS-White35-2 | — | — | — |
| 1 | — | — | W20 | — | 0.5 | PROTEUS-White35-23 | — | — | — |
| 1 | — | — | W21 | — | 0.5 | PROTEUS-White35-29 | — | — | — |
| 1 | — | — | W22 | — | 0.5 | PROTEUS-White35-3 | — | — | — |
| 1 | — | — | W23 | — | 0.5 | PROTEUS-White35-4 | — | — | — |
| 1 | — | — | W24 | — | 0.5 | PROTEUS-White35-5 | — | — | — |
| 1 | — | — | W25 | — | 0.5 | PROTEUS-White35-6 | — | — | — |
| 1 | — | — | W26 | — | 0.5 | PROTEUS-White35-7 | — | — | — |
| 1 | — | — | W27 | — | 0.5 | PROTEUS-White35-8 | — | — | — |
SP-14V
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | — | — | W1 | — | 0.85 | OEM-B-1 | — | — | — |
| 1 | — | — | W2 | — | 0.85 | OEM-B-9 | — | — | — |
| 1 | — | — | W3 | — | 0.85 | PROTEUS-Black23-23 | — | — | — |
SP-GND
| Cavity | Function | Signal | Wire | Colour | Gauge (mm²) | Destination | Terminal | Seal | Plug |
|---|---|---|---|---|---|---|---|---|---|
| 1 | — | — | W4 | — | 0.85 | OEM-B-10 | — | — | — |
| 1 | — | — | W5 | — | 0.85 | OEM-B-2 | — | — | — |
| 1 | — | — | W6 | — | 0.85 | OEM-B-20 | — | — | — |
| 1 | — | — | W7 | — | 0.85 | OEM-B-22 | — | — | — |
| 1 | — | — | W8 | — | 0.85 | PROTEUS-Black23-14 | — | — | — |
| 1 | — | — | W9 | — | 0.85 | PROTEUS-Black23-19 | — | — | — |
| 1 | — | — | W10 | — | 0.85 | PROTEUS-Black23-20 | — | — | — |
| 1 | — | — | W11 | — | 0.85 | PROTEUS-Black35-17 | — | — | — |
| 1 | — | — | W12 | — | 0.85 | PROTEUS-Black35-18 | — | — | — |
| 1 | — | — | W13 | — | 0.85 | PROTEUS-Black35-24 | — | — | — |
Pin map
| OEM point | OEM function | OEM family | Target point | Target function | Target family | Wire colour | Evidence |
|---|---|---|---|---|---|---|---|
| OEM-A-1 | Coolant temp gauge drive | low_side_out | PROTEUS-Black35-6 | Injector 6 | injector_out | corroborated | |
| OEM-A-10 | Service check signal | — | — | — | — | single_source | |
| OEM-A-11 | NC | — | — | — | — | unverified | |
| OEM-A-12 | Immobilizer indicator light | low_side_out | PROTEUS-Black35-7 | Injector 7 | injector_out | single_source | |
| OEM-A-13 | Immobilizer enable signal | — | — | — | — | single_source | |
| OEM-A-14 | NC | — | — | — | — | unverified | |
| OEM-A-15 | Fuel pump relay (USDM) | low_side_out | PROTEUS-Black35-20 | Lowside 10 | low_side_out | corroborated | |
| OEM-A-16 | Fuel pump relay (JDM) | low_side_out | PROTEUS-Black35-9 | Lowside 11 | low_side_out | single_source | |
| OEM-A-17 | A/C clutch relay | low_side_out | PROTEUS-Black35-21 | Lowside 12 | low_side_out | corroborated | |
| OEM-A-18 | Check engine light (MIL) | low_side_out | PROTEUS-Black35-19 | Injector 8 | injector_out | corroborated | |
| OEM-A-19 | Tacho output | tacho_out | — | — | — | corroborated | |
| OEM-A-2 | Air control valve solenoid | low_side_out | PROTEUS-Black35-8 | Injector 9 | injector_out | single_source | |
| OEM-A-20 | Radiator fan relay | low_side_out | PROTEUS-Black35-10 | Lowside 13 | low_side_out | corroborated | |
| OEM-A-21 | K-Line | serial | — | — | — | single_source | |
| OEM-A-22 | NC | — | — | — | — | unverified | |
| OEM-A-23 | Secondary O2 sensor | lambda_nb_in | PROTEUS-White35-14 | Analog Volt 3 | analog_in | single_source | |
| OEM-A-24 | Starter switch signal | digital_in | PROTEUS-Black23-3 | Digital 4 | digital_in | corroborated | |
| OEM-A-25 | Immobilizer code | — | — | — | — | single_source | |
| OEM-A-26 | Power steering load detect | digital_in | PROTEUS-Black23-9 | Digital 5 | digital_in | corroborated | |
| OEM-A-27 | A/C switch (request) | digital_in | PROTEUS-Black23-11 | Digital 6 | digital_in | corroborated | |
| OEM-A-28 | Air pump relay | low_side_out | PROTEUS-Black35-11 | Lowside 14 | low_side_out | corroborated | |
| OEM-A-29 | Fuel tank pressure sensor | analog_in | PROTEUS-White35-26 | Analog Volt 6 | analog_in | corroborated | |
| OEM-A-3 | Evap bypass solenoid | low_side_out | PROTEUS-Black23-6 | ETB 1 negative | hbridge_out | single_source | |
| OEM-A-30 | Electrical load detector | analog_in | PROTEUS-White35-16 | Analog Volt 7 | analog_in | corroborated | |
| OEM-A-31 | NC | — | — | — | — | unverified | |
| OEM-A-32 | Brake switch | digital_in | PROTEUS-White35-17 | Analog Volt 9 | analog_in | corroborated | |
| OEM-A-4 | Evap canister vent shut valve | low_side_out | PROTEUS-Black23-7 | ETB 1 positive | hbridge_out | single_source | |
| OEM-A-5 | NC | — | — | — | — | unverified | |
| OEM-A-6 | Evap canister purge valve | low_side_out | PROTEUS-Black23-15 | ETB 2 positive | hbridge_out | single_source | |
| OEM-A-7 | NC | — | — | — | — | unverified | |
| OEM-A-8 | NC | — | — | — | — | unverified | |
| OEM-A-9 | Vehicle speed sensor | digital_in | PROTEUS-Black23-2 | Digital 3 | digital_in | corroborated | |
| OEM-B-1 | Power source 1 (main relay) | power_in | PROTEUS-Black23-23 | Main relay feed | power_in | corroborated | |
| OEM-B-10 | Power ground 2 | ground | PROTEUS-Black23-14 + PROTEUS-Black23-19 + PROTEUS-Black23-20 + PROTEUS-Black35-17 + PROTEUS-Black35-18 + PROTEUS-Black35-24 | Power ground + Power ground + Power ground + Power ground + Power ground + Power ground | ground | single_source | |
| OEM-B-11 | Injector 1 | injector_out | PROTEUS-Black35-3 | Injector 1 | injector_out | corroborated | |
| OEM-B-12 | VTEC solenoid | high_side_out | PROTEUS-Black35-2 | Highside 1 | high_side_out | corroborated | |
| OEM-B-13 | NC | — | — | — | — | unverified | |
| OEM-B-14 | NC | — | — | — | — | unverified | |
| OEM-B-15 | NC | — | — | — | — | unverified | |
| OEM-B-16 | NC | — | — | — | — | unverified | |
| OEM-B-17 | NC | — | — | — | — | unverified | |
| OEM-B-18 | NC | — | — | — | — | unverified | |
| OEM-B-19 | NC | — | — | — | — | unverified | |
| OEM-B-2 | Power ground 1 | ground | PROTEUS-Black23-14 + PROTEUS-Black23-19 + PROTEUS-Black23-20 + PROTEUS-Black35-17 + PROTEUS-Black35-18 + PROTEUS-Black35-24 | Power ground + Power ground + Power ground + Power ground + Power ground + Power ground | ground | corroborated | |
| OEM-B-20 | Ground | ground | PROTEUS-Black23-14 + PROTEUS-Black23-19 + PROTEUS-Black23-20 + PROTEUS-Black35-17 + PROTEUS-Black35-18 + PROTEUS-Black35-24 | Power ground + Power ground + Power ground + Power ground + Power ground + Power ground | ground | single_source | |
| OEM-B-21 | Backup power (battery constant) | power_in | — | — | — | single_source | |
| OEM-B-22 | Ground | ground | PROTEUS-Black23-14 + PROTEUS-Black23-19 + PROTEUS-Black23-20 + PROTEUS-Black35-17 + PROTEUS-Black35-18 + PROTEUS-Black35-24 | Power ground + Power ground + Power ground + Power ground + Power ground + Power ground | ground | single_source | |
| OEM-B-23 | Idle air control valve | low_side_out | PROTEUS-Black35-5 | Injector 5 | injector_out | corroborated | |
| OEM-B-24 | NC | — | — | — | — | unverified | |
| OEM-B-25 | NC | — | — | — | — | unverified | |
| OEM-B-3 | Injector 2 | injector_out | PROTEUS-Black35-15 | Injector 2 | injector_out | corroborated | |
| OEM-B-4 | Injector 3 | injector_out | PROTEUS-Black35-4 | Injector 3 | injector_out | corroborated | |
| OEM-B-5 | Injector 4 | injector_out | PROTEUS-Black35-16 | Injector 4 | injector_out | corroborated | |
| OEM-B-6 | NC | — | — | — | — | unverified | |
| OEM-B-7 | NC | — | — | — | — | unverified | |
| OEM-B-8 | NC | — | — | — | — | unverified | |
| OEM-B-9 | Power source 2 (main relay) | power_in | PROTEUS-Black23-23 | Main relay feed | power_in | corroborated | |
| OEM-C-1 | Primary O2 heater | low_side_out | PROTEUS-Black35-12 | Lowside 15 | low_side_out | corroborated | |
| OEM-C-10 | VTEC pressure switch | digital_in | PROTEUS-White35-28 | Analog Volt 10 | analog_in | corroborated | |
| OEM-C-11 | Secondary O2 heater control | low_side_out | PROTEUS-Black35-23 | Lowside 16 | low_side_out | single_source | |
| OEM-C-12 | Ignition coil 2 | ignition_out | PROTEUS-Black35-34 | Ignition 2 | ignition_out | corroborated | |
| OEM-C-13 | Ignition coil 3 | ignition_out | PROTEUS-Black35-22 | Ignition 3 | ignition_out | corroborated | |
| OEM-C-14 | Ignition coil 4 | ignition_out | PROTEUS-Black35-33 | Ignition 4 | ignition_out | corroborated | |
| OEM-C-15 | Secondary O2 sensor | lambda_nb_in | PROTEUS-White35-25 | Analog Volt 4 | analog_in | corroborated | |
| OEM-C-16 | Primary O2 sensor | lambda_nb_in | PROTEUS-White35-15 | Analog Volt 5 | analog_in | corroborated | |
| OEM-C-17 | MAP sensor | analog_in | PROTEUS-White35-13 | Analog Volt 1 | analog_in | corroborated | |
| OEM-C-18 | Sensor ground 2 | sensor_ground | PROTEUS-White35-1 + PROTEUS-White35-2 + PROTEUS-White35-23 + PROTEUS-White35-29 + PROTEUS-White35-3 + PROTEUS-White35-4 + PROTEUS-White35-5 + PROTEUS-White35-6 + PROTEUS-White35-7 + PROTEUS-White35-8 | Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground | sensor_ground | corroborated | |
| OEM-C-19 | Sensor 5V supply 1 (MAP) | vref | PROTEUS-White35-10 | 5V supply #2 | vref | corroborated | |
| OEM-C-2 | Alternator control | low_side_out | PROTEUS-Black23-8 | ETB 2 negative | hbridge_out | single_source | |
| OEM-C-20 | Cam (TDC1) sensor + | trigger_in | PROTEUS-Black23-4 | VR 2 positive | trigger_in | corroborated | |
| OEM-C-21 | Cam (TDC1) sensor − | trigger_in | PROTEUS-Black23-12 | VR 2 negative | trigger_in | corroborated | |
| OEM-C-22 | Knock sensor | knock_in | — | — | — | conflict | |
| OEM-C-23 | NC | — | — | — | — | unverified | |
| OEM-C-24 | Air pump electric current sensor | analog_in | PROTEUS-White35-27 | Analog Volt 8 | analog_in | single_source | |
| OEM-C-25 | Intake air temp sensor | temp_in | PROTEUS-White35-30 | Intake air temp (IAT) | temp_in | corroborated | |
| OEM-C-26 | Coolant temp sensor | temp_in | PROTEUS-White35-20 | Coolant temp (CLT) | temp_in | corroborated | |
| OEM-C-27 | Throttle position sensor | analog_in | PROTEUS-White35-24 | Analog Volt 2 | analog_in | corroborated | |
| OEM-C-28 | Sensor 5V supply 2 | vref | PROTEUS-White35-21 | 5V supply #1 | vref | corroborated | |
| OEM-C-29 | Cam (TDC2) sensor + | trigger_in | PROTEUS-Black23-1 | Digital 2 | trigger_in | corroborated | |
| OEM-C-3 | Knock sensor | knock_in | — | — | — | conflict | |
| OEM-C-30 | Cam (TDC2) sensor − | sensor_ground | PROTEUS-White35-1 + PROTEUS-White35-2 + PROTEUS-White35-23 + PROTEUS-White35-29 + PROTEUS-White35-3 + PROTEUS-White35-4 + PROTEUS-White35-5 + PROTEUS-White35-6 + PROTEUS-White35-7 + PROTEUS-White35-8 | Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground | sensor_ground | corroborated | |
| OEM-C-31 | Timing ground | sensor_ground | PROTEUS-White35-1 + PROTEUS-White35-2 + PROTEUS-White35-23 + PROTEUS-White35-29 + PROTEUS-White35-3 + PROTEUS-White35-4 + PROTEUS-White35-5 + PROTEUS-White35-6 + PROTEUS-White35-7 + PROTEUS-White35-8 | Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground | sensor_ground | single_source | |
| OEM-C-4 | Ignition coil 1 | ignition_out | PROTEUS-Black35-35 | Ignition 1 | ignition_out | corroborated | |
| OEM-C-5 | Alternator FR signal | digital_in | PROTEUS-Black23-10 | Digital 1 | digital_in | single_source | |
| OEM-C-6 | NC | — | — | — | — | unverified | |
| OEM-C-7 | Sensor ground 1 | sensor_ground | PROTEUS-White35-1 + PROTEUS-White35-2 + PROTEUS-White35-23 + PROTEUS-White35-29 + PROTEUS-White35-3 + PROTEUS-White35-4 + PROTEUS-White35-5 + PROTEUS-White35-6 + PROTEUS-White35-7 + PROTEUS-White35-8 | Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground + Sensor ground | sensor_ground | corroborated | |
| OEM-C-8 | Crank sensor + (CKP+) | trigger_in | PROTEUS-Black23-5 | VR 1 positive | trigger_in | corroborated | |
| OEM-C-9 | Crank sensor − (CKP−) | trigger_in | PROTEUS-Black23-13 | VR 1 negative | trigger_in | corroborated | |
| OEM-D-1 | NC | — | — | — | — | unverified | |
| OEM-D-10 | NC | — | — | — | — | unverified | |
| OEM-D-11 | NC | — | — | — | — | unverified | |
| OEM-D-12 | NC | — | — | — | — | unverified | |
| OEM-D-13 | NC | — | — | — | — | unverified | |
| OEM-D-14 | NC | — | — | — | — | unverified | |
| OEM-D-15 | NC | — | — | — | — | unverified | |
| OEM-D-16 | NC | — | — | — | — | unverified | |
| OEM-D-2 | NC | — | — | — | — | unverified | |
| OEM-D-3 | NC | — | — | — | — | unverified | |
| OEM-D-4 | NC | — | — | — | — | unverified | |
| OEM-D-5 | NC | — | — | — | — | unverified | |
| OEM-D-6 | NC | — | — | — | — | unverified | |
| OEM-D-7 | NC | — | — | — | — | unverified | |
| OEM-D-8 | NC | — | — | — | — | unverified | |
| OEM-D-9 | NC | — | — | — | — | unverified |
Cut list
| Wire | From | To | Gauge (mm²) | Colour | Length | Signal | Ident |
|---|---|---|---|---|---|---|---|
| W1 | OEM-B-1 | SP-14V-1 | 0.85 | no route | Power source 1 (main relay) | — | |
| W2 | OEM-B-9 | SP-14V-1 | 0.85 | no route | Power source 2 (main relay) | — | |
| W3 | SP-14V-1 | PROTEUS-Black23-23 | 0.85 | no route | Main relay feed | — | |
| W4 | OEM-B-10 | SP-GND-1 | 0.85 | no route | Power ground 2 | — | |
| W5 | OEM-B-2 | SP-GND-1 | 0.85 | no route | Power ground 1 | — | |
| W6 | OEM-B-20 | SP-GND-1 | 0.85 | no route | Ground | — | |
| W7 | OEM-B-22 | SP-GND-1 | 0.85 | no route | Ground | — | |
| W8 | SP-GND-1 | PROTEUS-Black23-14 | 0.85 | no route | Power ground | — | |
| W9 | SP-GND-1 | PROTEUS-Black23-19 | 0.85 | no route | Power ground | — | |
| W10 | SP-GND-1 | PROTEUS-Black23-20 | 0.85 | no route | Power ground | — | |
| W11 | SP-GND-1 | PROTEUS-Black35-17 | 0.85 | no route | Power ground | — | |
| W12 | SP-GND-1 | PROTEUS-Black35-18 | 0.85 | no route | Power ground | — | |
| W13 | SP-GND-1 | PROTEUS-Black35-24 | 0.85 | no route | Power ground | — | |
| W14 | OEM-C-18 | SP-0V-1 | 0.5 | no route | Sensor ground 2 | — | |
| W15 | OEM-C-30 | SP-0V-1 | 0.5 | no route | Cam (TDC2) sensor − | — | |
| W16 | OEM-C-31 | SP-0V-1 | 0.5 | no route | Timing ground | — | |
| W17 | OEM-C-7 | SP-0V-1 | 0.5 | no route | Sensor ground 1 | — | |
| W18 | SP-0V-1 | PROTEUS-White35-1 | 0.5 | no route | Sensor ground | — | |
| W19 | SP-0V-1 | PROTEUS-White35-2 | 0.5 | no route | Sensor ground | — | |
| W20 | SP-0V-1 | PROTEUS-White35-23 | 0.5 | no route | Sensor ground | — | |
| W21 | SP-0V-1 | PROTEUS-White35-29 | 0.5 | no route | Sensor ground | — | |
| W22 | SP-0V-1 | PROTEUS-White35-3 | 0.5 | no route | Sensor ground | — | |
| W23 | SP-0V-1 | PROTEUS-White35-4 | 0.5 | no route | Sensor ground | — | |
| W24 | SP-0V-1 | PROTEUS-White35-5 | 0.5 | no route | Sensor ground | — | |
| W25 | SP-0V-1 | PROTEUS-White35-6 | 0.5 | no route | Sensor ground | — | |
| W26 | SP-0V-1 | PROTEUS-White35-7 | 0.5 | no route | Sensor ground | — | |
| W27 | SP-0V-1 | PROTEUS-White35-8 | 0.5 | no route | Sensor ground | — | |
| W28 | OEM-C-19 | PROTEUS-White35-10 | 0.5 | no route | Sensor 5V supply 1 (MAP) | — | |
| W29 | OEM-C-28 | PROTEUS-White35-21 | 0.5 | no route | Sensor 5V supply 2 | — | |
| W30 | OEM-C-9 | PROTEUS-Black23-13 | 0.5 | no route | Crank sensor − (CKP−) | — | |
| W31 | OEM-C-8 | PROTEUS-Black23-5 | 0.5 | no route | Crank sensor + (CKP+) | — | |
| W32 | OEM-C-21 | PROTEUS-Black23-12 | 0.5 | no route | Cam (TDC1) sensor − | — | |
| W33 | OEM-C-20 | PROTEUS-Black23-4 | 0.5 | no route | Cam (TDC1) sensor + | — | |
| W34 | OEM-C-29 | PROTEUS-Black23-1 | 0.5 | no route | Cam (TDC2) sensor + | — | |
| W35 | OEM-C-4 | PROTEUS-Black35-35 | 0.5 | no route | Ignition coil 1 | — | |
| W36 | OEM-C-12 | PROTEUS-Black35-34 | 0.5 | no route | Ignition coil 2 | — | |
| W37 | OEM-C-13 | PROTEUS-Black35-22 | 0.5 | no route | Ignition coil 3 | — | |
| W38 | OEM-C-14 | PROTEUS-Black35-33 | 0.5 | no route | Ignition coil 4 | — | |
| W39 | OEM-B-11 | PROTEUS-Black35-3 | 0.5 | no route | Injector 1 | — | |
| W40 | OEM-B-3 | PROTEUS-Black35-15 | 0.5 | no route | Injector 2 | — | |
| W41 | OEM-B-4 | PROTEUS-Black35-4 | 0.5 | no route | Injector 3 | — | |
| W42 | OEM-B-5 | PROTEUS-Black35-16 | 0.5 | no route | Injector 4 | — | |
| W43 | OEM-A-15 | PROTEUS-Black35-20 | 0.5 | no route | Fuel pump relay (USDM) | — | |
| W44 | OEM-A-16 | PROTEUS-Black35-9 | 0.5 | no route | Fuel pump relay (JDM) | — | |
| W45 | OEM-A-17 | PROTEUS-Black35-21 | 0.5 | no route | A/C clutch relay | — | |
| W46 | OEM-A-20 | PROTEUS-Black35-10 | 0.5 | no route | Radiator fan relay | — | |
| W47 | OEM-A-28 | PROTEUS-Black35-11 | 0.5 | no route | Air pump relay | — | |
| W48 | OEM-B-12 | PROTEUS-Black35-2 | 0.5 | no route | VTEC solenoid | — | |
| W49 | OEM-C-1 | PROTEUS-Black35-12 | 0.5 | no route | Primary O2 heater | — | |
| W50 | OEM-C-11 | PROTEUS-Black35-23 | 0.5 | no route | Secondary O2 heater control | — | |
| W51 | OEM-B-23 | PROTEUS-Black35-5 | 0.5 | no route | Idle air control valve | — | |
| W52 | OEM-A-1 | PROTEUS-Black35-6 | 0.5 | no route | Coolant temp gauge drive | — | |
| W53 | OEM-A-12 | PROTEUS-Black35-7 | 0.5 | no route | Immobilizer indicator light | — | |
| W54 | OEM-A-18 | PROTEUS-Black35-19 | 0.5 | no route | Check engine light (MIL) | — | |
| W55 | OEM-A-2 | PROTEUS-Black35-8 | 0.5 | no route | Air control valve solenoid | — | |
| W56 | OEM-A-3 | PROTEUS-Black23-6 | 0.5 | no route | Evap bypass solenoid | — | |
| W57 | OEM-A-4 | PROTEUS-Black23-7 | 0.5 | no route | Evap canister vent shut valve | — | |
| W58 | OEM-A-6 | PROTEUS-Black23-15 | 0.5 | no route | Evap canister purge valve | — | |
| W59 | OEM-C-2 | PROTEUS-Black23-8 | 0.5 | no route | Alternator control | — | |
| W60 | OEM-C-17 | PROTEUS-White35-13 | 0.5 | no route | MAP sensor | — | |
| W61 | OEM-C-27 | PROTEUS-White35-24 | 0.5 | no route | Throttle position sensor | — | |
| W62 | OEM-A-23 | PROTEUS-White35-14 | 0.5 | no route | Secondary O2 sensor | — | |
| W63 | OEM-C-15 | PROTEUS-White35-25 | 0.5 | no route | Secondary O2 sensor | — | |
| W64 | OEM-C-16 | PROTEUS-White35-15 | 0.5 | no route | Primary O2 sensor | — | |
| W65 | OEM-C-26 | PROTEUS-White35-20 | 0.5 | no route | Coolant temp sensor | — | |
| W66 | OEM-C-25 | PROTEUS-White35-30 | 0.5 | no route | Intake air temp sensor | — | |
| W67 | OEM-A-29 | PROTEUS-White35-26 | 0.5 | no route | Fuel tank pressure sensor | — | |
| W68 | OEM-A-30 | PROTEUS-White35-16 | 0.5 | no route | Electrical load detector | — | |
| W69 | OEM-C-24 | PROTEUS-White35-27 | 0.5 | no route | Air pump electric current sensor | — | |
| W70 | OEM-A-9 | PROTEUS-Black23-2 | 0.5 | no route | Vehicle speed sensor | — | |
| W71 | OEM-C-5 | PROTEUS-Black23-10 | 0.5 | no route | Alternator FR signal | — | |
| W72 | OEM-A-24 | PROTEUS-Black23-3 | 0.5 | no route | Starter switch signal | — | |
| W73 | OEM-A-26 | PROTEUS-Black23-9 | 0.5 | no route | Power steering load detect | — | |
| W74 | OEM-A-27 | PROTEUS-Black23-11 | 0.5 | no route | A/C switch (request) | — | |
| W75 | OEM-A-32 | PROTEUS-White35-17 | 0.5 | no route | Brake switch | — | |
| W76 | OEM-C-10 | PROTEUS-White35-28 | 0.5 | no route | VTEC pressure switch | — |
Bill of materials
| Category | Part number | Manufacturer | Description | Qty | Unit |
|---|---|---|---|---|---|
| connector | 179679-6 | TE | S2000 2000–05 ECU harness plug B (25P, TE 040 Multi-Lock) | 1.000 | ea |
| connector | 179680-5 | TE | S2000 2000–05 ECU harness plug C (31P, TE 040 Multi-Lock) | 1.000 | ea |
| connector | 179681-6 | TE | S2000 2000–05 ECU harness plug A (32P, TE 040 Multi-Lock) | 1.000 | ea |
| connector | S2K-0005-ECU-D | Honda | S2000 2000–05 ECU plug D (P/N unknown) | 1.000 | ea |
ECU setup sheet
| Role | Engine ref | Engine signal | Sensor | ECU point | ECU function | ECU class | Setup flag |
|---|---|---|---|---|---|---|---|
| No configured channels. | |||||||
Findings
Open (12)
| Severity | Code | Subject | Message |
|---|---|---|---|
| warn | NET_FAMILY | OEM-A-3 ↔ PROTEUS-Black23-6 | OEM-A-3 "Evap bypass solenoid" [low_side_out] is wired to PROTEUS-Black23-6 "ETB 1 negative" [hbridge_out]. A half-bridge can act as a low-side switch only if configured that way. |
| warn | NET_FAMILY | OEM-A-32 ↔ PROTEUS-White35-17 | OEM-A-32 "Brake switch" [digital_in] is wired to PROTEUS-White35-17 "Analog Volt 9" [analog_in]. Analog and digital on one net. A switch on an analog input works with a pull-up and a threshold; an analog sensor on a digital input loses its value. |
| warn | NET_FAMILY | OEM-A-4 ↔ PROTEUS-Black23-7 | OEM-A-4 "Evap canister vent shut valve" [low_side_out] is wired to PROTEUS-Black23-7 "ETB 1 positive" [hbridge_out]. A half-bridge can act as a low-side switch only if configured that way. |
| warn | NET_FAMILY | OEM-A-6 ↔ PROTEUS-Black23-15 | OEM-A-6 "Evap canister purge valve" [low_side_out] is wired to PROTEUS-Black23-15 "ETB 2 positive" [hbridge_out]. A half-bridge can act as a low-side switch only if configured that way. |
| warn | NET_FAMILY | OEM-C-10 ↔ PROTEUS-White35-28 | OEM-C-10 "VTEC pressure switch" [digital_in] is wired to PROTEUS-White35-28 "Analog Volt 10" [analog_in]. Analog and digital on one net. A switch on an analog input works with a pull-up and a threshold; an analog sensor on a digital input loses its value. |
| warn | NET_FAMILY | OEM-C-2 ↔ PROTEUS-Black23-8 | OEM-C-2 "Alternator control" [low_side_out] is wired to PROTEUS-Black23-8 "ETB 2 negative" [hbridge_out]. A half-bridge can act as a low-side switch only if configured that way. |
| info | NET_FAMILY | OEM-A-1 ↔ PROTEUS-Black35-6 | OEM-A-1 "Coolant temp gauge drive" [low_side_out] is wired to PROTEUS-Black35-6 "Injector 6" [injector_out]. Injector drivers can usually run general low-side loads; check current and PWM frequency. |
| info | NET_FAMILY | OEM-A-12 ↔ PROTEUS-Black35-7 | OEM-A-12 "Immobilizer indicator light" [low_side_out] is wired to PROTEUS-Black35-7 "Injector 7" [injector_out]. Injector drivers can usually run general low-side loads; check current and PWM frequency. |
| info | NET_FAMILY | OEM-A-18 ↔ PROTEUS-Black35-19 | OEM-A-18 "Check engine light (MIL)" [low_side_out] is wired to PROTEUS-Black35-19 "Injector 8" [injector_out]. Injector drivers can usually run general low-side loads; check current and PWM frequency. |
| info | NET_FAMILY | OEM-A-2 ↔ PROTEUS-Black35-8 | OEM-A-2 "Air control valve solenoid" [low_side_out] is wired to PROTEUS-Black35-8 "Injector 9" [injector_out]. Injector drivers can usually run general low-side loads; check current and PWM frequency. |
| info | NET_FAMILY | OEM-B-23 ↔ PROTEUS-Black35-5 | OEM-B-23 "Idle air control valve" [low_side_out] is wired to PROTEUS-Black35-5 "Injector 5" [injector_out]. Injector drivers can usually run general low-side loads; check current and PWM frequency. |
| info | UNMAPPED | OEM | 8 optional OEM pins are not mapped: OEM-A-10 Service check signal; OEM-A-13 Immobilizer enable signal; OEM-A-19 Tacho output; OEM-A-21 K-Line; OEM-A-25 Immobilizer code; OEM-B-21 Backup power (battery constant); OEM-C-22 Knock sensor; OEM-C-3 Knock sensor |
Accepted (0)
| Code | Subject | Reason | By |
|---|
Notes
Fit check: unconfirmed. Confirm these before building: - Trigger pattern for Honda F22C1 not found in the ECU's docs (no S2000/F20C/F22C1 trigger decoder (Honda set: K cam 4+1, K crank 1/12, J30A2 24+1+1, CBR600, OBD1 distributor)) Auto-mapped by auto_map() from the library pin data on 2026-10-06. Review every wire against both manuals before building. Not wired: - OEM-B 21: Backup power (battery constant): rusEFI Proteus has no battery-constant input; not needed - OEM-C 22: Knock sensor: 2 stock pins named "Knock sensor" without a documented polarity / pairing; wire by hand - OEM-C 3: Knock sensor: 2 stock pins named "Knock sensor" without a documented polarity / pairing; wire by hand - OEM-A 19: Tacho output: no free tacho/frequency_out/low_side/ls_hs on rusEFI Proteus - OEM-A 21: K-Line: no free k_line on rusEFI Proteus - OEM-A 10: Service check signal: not classified in the library; wire by hand - OEM-A 13: Immobilizer enable signal: not classified in the library; wire by hand - OEM-A 25: Immobilizer code: not classified in the library; wire by hand - PROTEUS-Black23 18: Ignition switch in: not fed (the stock ECU has no ignition-sense pin); feed it from a switched-ignition source
Sources
| Reliability | Kind | Title | URL | Archive | Captured | SHA-256 |
|---|---|---|---|---|---|---|
| 4 | vendor_doc | AEM 30-6052 Series 2 Plug & Play EMS, 2000–2005 S2000 (original ECU pinout) | https://documents.aemelectronics.com/techlibrary_30-6052_series_2_plug___play_ems.pdf | — | 2026-10-05 | 9f79620fff5a |
| 4 | vendor_doc | Haltech KB: F20C (AP1) engine | https://support.haltech.com/portal/en/kb/articles/f20c-ap1-engine | — | 2026-10-05 | e804da29d014 |
| 4 | vendor_doc | Link S2000 AP1 PlugIn installation manual | https://linkecu.com/documentation/S2000X.pdf | — | 2026-10-05 | d12b0ff3f006 |
| 4 | vendor_doc | rusEFI Proteus — board connector definitions (Black35 / White35 / Black23) | https://github.com/rusefi/rusefi/tree/master/firmware/config/boards/proteus/connectors | archive | 2026-10-05 | 738a2ea934c0 |
| 2 | forum | AllPinouts: 2000–2005 Honda S2000 ECU | https://allpinouts.org/pinouts/connectors/car/2000-2005-honda-s2000-ecu/ | archive | 2026-10-05 | 81d874e0385d |
| 2 | forum | Autodata blog: ECU Pinout Honda S2000 2000-2004 | http://autodatas.blogspot.com/2012/11/ecu-pinout-honda-s2000-2000-2004.html | — | 2026-10-05 | 33b93af7640e |
| 2 | derived | Typical load estimates (relay coil ~0.2 A, high-Z injector ~1.2 A, VVT solenoid ~1 A) | — | — | — | — |